CLTTC100G Truck Crane

This product has been discontinued and removed from our shelves.

Tips
1. Over load and slant dragging is prohibited.
2. Pay special attention to the counterweight and the supporting leg when check the lifting capability reference table.
3. All these parameters are measured under the condition that the truck is static on the solid ground and the platform had been regulated to be at level. The luffing ranges in list are measured under the condition of rated load.
4. The rated lifting capacity includes the weight of 100t host lifting hook of 1.1t and the 50t auxiliary lifting hook of 0.45t as well as another 6t auxiliary lifting hook of 0.25t. When the auxiliary boom is fully extended, the actual lifting capacity of the host lifting boom should be 1.85t lower than the rated value.
5. If the host lifting hook is at the end of host boom arm, the actual lifting capacity of auxiliary boom should be 0.35t lower than the rated value, and actual lifting capacity of every boom section supported by the boom-end single pulley should be 0.4t lower than the rated value and limited within 6t.
When the auxiliary lifting hook is on the boom-end single pulley, the actual lifting capacity of each section of the host boom will be 0.3t lower than the rated value.
6. Under the condition of not using the fifth supporting leg, the truck crane is forbidden to lift any weight within the 120° sector in front of itself. Only after the fifth supporting leg is mounted can the equipment finish the lifting task 360° all around itself.
7. Please make sure the boom length in the list you refer to is longer than your actual boom length, and arrange the lifting task no heavier than the smallest rate lifting capacity suggested by the list for the sake of safety.
8. At the end of the table are the minimum luffing angles under different boom lengths. It will be risky to lower the boom down below these minimum luffing angles.

Technical Parameters (truck)
Dimensions Length mm 15300
Width mm 2800
Height mm 3890
Wheel base First-Second mm 1450
Second-Third mm 3750
Third-Forth mm 1450
Forth-Fifth mm 1450
Load capacity Self weight kg 54990
Axle load Fore shaft kg 19380
Aft shaft kg 35610
Kinetic parameters Engine Loaded Rated power kW/(r/min) 140/1900
Rated torque N.m/(r/min) 850/1300~1400
Unloaded Rated power kW/(r/min) 306/1900
Rated torque N.m/(r/min) 2010/1200~1300
Traveling parameters Maximum driving speed km/h 77
Minimum turning diameter m 23
Minimum ground clearance mm 290
Approach angle ° 22.5
Departure angle ° 15
Braking length(30km/h) m 10
Maximum climbing capacity % 41
Fuel consumption per 100 km L 62
Technical Parameter (crane)
Performance parameters Maximum lifting capacity t 100
Minimum rated Luffing range m 3
The platform tail slewing radius mm 4572
Maximum lifting torque Standard kN.m 3293
Supporting leg interval Longitude m 6.65
Transversal m 7.8
Lifting height Standard m 13.3
Longest (host boom) m 48.8
Longest (host and auxiliary boom) m 67
Boom length Standard m 12.6
Longest (host boom) m 48.2
Longest ( host and auxiliary boom) m 66.7
Operation parameters Luffing time Full luffing s 56
Extension time Full extension s 119
Maximum slewing speed r/min 1.62
Maximum lifting speed of host boom with single rope (to the third level of height) m/min 121
Auxiliary lifting speed of auxiliary boom with single rope (to the third level of height) m/min 111
Load capacity parameters
Table1 (Counterweight: 15t, Full extended supporting legs, Host boom in 3600 working)(Unit: t)
Luffing range(m) Boom length
12.6m 17.05m 21.5m 25.95m 30.4m 34.85m 39.3m 43.75m 48.2m
3 100.0 75.0 　 　 　 　 　 　 　
4 78.0 68.0 54.0 　 　 　 　 　 　
5 66.0 60.0 46.5 32.0 30.0 　 　 　 　
6 56.0 52.0 40.7 32.0 30.0 27.0 　 　 　
7 46.0 44.0 36.0 31.1 29.0 26.2 22.0 　 　
8 38.0 38.0 32.2 28.0 26.1 23.7 21.4 18.0 　
9 32.0 32.0 29.0 25.3 23.6 21.6 19.7 17.5 12.0
10 26.0 27.0 26.4 23.0 21.4 19.7 18.2 17.0 12.0
11
22.0 23.0 21.1 19.6 18.2 16.8 15.7 12.0
12
19.0 19.0 19.4 18.0 16.8 14.5 14.6 12.0
14
14.5 14.5 15.0 15.2 14.4 12.2 12.5 11.4
16
　 11.0 12.0 12.5 12.4 10.5 10.9 10.0
18
　 8.5 9.5 10.0 10.5 9.0 9.5 8.9
20
　 　 7.5 8.2 8.6 7.4 8.4 7.8
22
　 　 6.0 6.5 7.0 6.0 7.4 7.0
24
　 　 　 5.3 5.8 5.0 6.3 6.2
26
　 　 　 4.3 4.7 4.2 5.3 5.6
28
　 　 　 　 4.0 3.6 4.4 4.7
30
　 　 　 　 3.2 3.3 3.7 4.0
32
　 　 　 　 　 2.8 3.1 3.3
34
　 　 　 　 　 　 2.6 2.8
36
　 　 　 　 　 　 　 2.3
38
　 　 　 　 　 　 　 1.8
Magnification 14 11 8 5 5 4 4 4 3
Smallest luffing angle of host boom 180 210 220 230 240 240 310 360 390
Hook weight 100t hook/1.1t 50t hook/0.45t
Table2 (Counterweight: 9t, Full extended supporting legs, host boom in 3600 working)(unit: t)
Luffing range(m) Boom length
12.6m 17.05m 21.5m 25.95m 30.4m 34.85m 39.3m 43.75m 48.2m
3 100.0 75.0 　 　 　 　 　 　 　
4 78.0 68.0 54.0 　 　 　 　 　 　
5 66.0 60.0 46.5 32.0 30.0 　 　 　 　
6 56.0 52.0 40.7 32.0 30.0 27.0 　 　 　
7 46.0 44.0 36.0 31.1 29.0 26.2 22.0 　 　
8 38.0 38.0 32.2 28.0 26.1 23.7 21.4 18.0 　
9 30.0 32.0 28.0 25.3 23.6 21.6 19.7 17.5 12.0
10 24.0 27.0 23.0 22.0 21.4 19.7 18.2 17.0 12.0
11 　 22.0 18.0 19.0 18.5 17.5 16.8 15.7 12.0
12 　 19.0 14.0 16.0 16.0 15.0 14.5 14.2 12.0
14 　 14.5 11.0 13.0 13.0 13.0 12.2 12.2 11.4
16 　 　 8.0 9.5 10.0 10.5 10.0 10.0 10.0
18 　 　 6.0 7.2 8.0 8.5 8.0 8.2 8.5
20 　 　 　 5.5 6.0 6.6 6.5 6.8 7.0
22 　 　 　 4.2 4.7 5.3 5.4 5.6 5.7
24 　 　 　 　 3.6 4.2 4.3 4.8 4.8
26 　 　 　 　 2.8 3.2 3.5 3.8 4.0
28 　 　 　 　 　 2.5 2.9 3.0 3.2
30 　 　 　 　 　 2.0 2.3 2.4 2.7
32 　 　 　 　 　 　 1.8 1.9 2.2
34 　 　 　 　 　 　 　 1.5 1.7
36 　 　 　 　 　 　 　 　 1.3
38 　 　 　 　 　 　 　 　 1.0
Magnification 14 11 8 5 5 4 4 4 3
Minimum luffing angle of host boom 180 210 220 230 240 320 360 400 420
Hook weight 100t hook/1.1t 50t hook/0.45t
Table 3(Counterweight: 2t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing range (m) Boom length
12.6m 17.05m 21.5m 25.95m 30.4m 34.85m 39.3m 43.75m 48.2m
3 90.0 75.0 　 　 　 　 　 　 　
4 78.0 68.0 54.0 　 　 　 　 　 　
5 66.0 60.0 46.5 32.0 30.0 　 　 　 　
6 52.0 52.0 40.7 32.0 30.0 27.0 　 　 　
7 40.0 42.0 36.0 30.0 28.0 26.2 22.0 　 　
8 30.0 32.0 28.0 25.0 24.0 23.0 21.4 18.0 　
9 24.0 25.0 22.0 21.0 21.0 20.0 19.0 17.5 12.0
10 18.0 20.0 17.5 18.0 18.0 17.5 16.5 16.0 12.0
11 　 17.0 14.2 15.2 15.5 15.2 15.0 14.0 12.0
12 　 14.0 11.8 12.8 13.0 13.0 13.0 12.5 12.0
14 　 11.0 8.0 9.2 9.8 10.0 10.4 10.0 10.0
16 　 　 5.6 6.5 7.3 7.7 8.2 7.7 8.0
18 　 　 3.8 4.8 5.5 5.8 6.2 6.2 6.5
20 　 　 　 3.3 4.0 4.4 4.8 5.1 5.2
22 　 　 　 2.2 2.9 3.3 3.7 4.0 4.1
24 　 　 　 　 2.0 2.4 2.8 3.1 3.3
26 　 　 　 　 1.3 1.7 2.0 2.3 2.5
28 　 　 　 　 　 1.1 1.4 1.7 1.9
30 　 　 　 　 　
0.9 1.2 1.4
32 　 　 　 　 　 　
0.8 1.0
Magnification 14 11 8 5 5 4 4 4 3
Minimum luffing angle 180 210 220 230 240 320 410 440 490
Hook weight 100t hook/1.1t 50t hook/0.45t
Table4 (Counterweight: 5t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing range (m) Boom length
12.6m 17.05m 21.5m 25.95m 30.4m 34.85m 39.3m 43.75m 48.2m
3 90.0 75.0 　 　 　 　 　 　 　
4 75.0 68.0 54.0 　 　 　 　 　 　
5 60.0 60.0 46.5 32.0 30.0 　 　 　 　
6 50.0 48.0 40.0 32.0 30.0 27.0 　 　 　
7 38.0 38.0 32.0 30.0 29.0 26.0 22.0 　 　
8 30.0 31.0 26.0 25.0 25.0 23.5 21.4 18.0 　
9 24.0 26.0 21.0 21.5 21.5 20.5 19.5 17.5 12.0
10 20.0 22.0 18.0 18.0 18.5 18.0 17.5 17.0 12.0
11 　 18.0 15.0 15.5 16.0 15.5 15.5 15.0 12.0
12 　 15.5 12.5 13.0 13.5 13.5 13.5 13.0 12.0
14 　 12.0 9.0 10.0 10.5 10.5 11.0 10.5 11.0
16 　 　 6.2 7.5 8.0 8.5 9.0 8.8 8.8
18 　 　 4.5 5.8 6.0 6.5 7.0 7.0 7.1
20 　 　 　 4.3 5.0 5.2 5.8 5.8 6.0
22 　 　 　 3.2 3.8 4.2 4.5 4.8 5.0
24 　 　 　 　 2.7 3.2 3.6 3.8 4.0
26 　 　 　 　 2.0 2.4 2.8 3.0 3.3
28 　 　 　 　 　 1.8 2.2 2.4 2.5
30 　 　 　 　 　 1.3 1.6 1.8 2.0
32 　 　 　 　 　 　 1.1 1.3 1.5
34 　 　 　 　 　 　 　 1.0 1.0
Magnification 14 11 8 5 5 4 4 4 3
Minimum luffing angle of host boom 180 210 220 230 240 320 360 400 430
Hook weight 100t hook/1.1t 50t hook/0.45t
Table 5(Counterweight: 9t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing range (m) Boom length
12.6m 17.05m 21.5m 25.95m 30.4m 34.85m 39.3m 43.75m 48.2m
3 90.0 75.0 　 　 　 　 　 　 　
4 70.0 65.0 54.0 　 　 　 　 　 　
5 55.0 52.0 43.0 32.0 30.0 　 　 　 　
6 41.0 40.0 33.0 28.0 27.0 26.0 　 　 　
7 31.0 32.0 26.0 24.0 23.0 23.0 20.0 　 　
8 24.0 26.0 21.0 20.0 20.0 19.0 18.0 17.0 　
9 19.0 21.0 17.5 17.0 17.0 16.0 16.0 15.0 12.0
10 16.0 17.6 14.0 14.2 14.0 13.7 14.0 13.0 12.0
11 　 15.0 11.5 12.0 12.0 12.0 12.0 11.5 11.0
12 　 13.0 9.3 10.0 10.0 10.5 10.0 10.0 9.5
14 　 10.0 6.4 7.6 8.0 8.5 8.0 8.2 8.0
16 　 　 4.3 5.5 6.2 6.5 6.5 6.5 6.5
18 　 　 3.0 3.8 4.3 5.0 5.3 5.3 5.3
20 　 　 　 2.7 3.2 3.7 4.0 4.2 4.3
22 　 　 　 1.7 2.2 2.7 3.0 3.3 3.5
24 　 　 　 　 1.5 1.9 2.2 2.5 2.6
26 　 　 　 　 0.9 1.3 1.6 1.8 2.0
28 　 　 　 　 　
1.0 1.2 1.5
30 　 　 　 　 　


1.0
Magnification 14 11 8 5 5 4 4 4 3
Minimum luffing angle of host boom 180 210 220 230 320 360 460 480 490
Hook weight 100t hook/1.1t 50t hook/0.45t
Table 6(Counterweight: 2t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing range (m) Boom length
12.6m 17.05m 21.5m 25.95m 30.4m 34.85m 39.3m 43.75m 48.2m
3 90.0 75.0 　 　 　 　 　 　 　
4 65.0 62.0 50.0 　 　 　 　 　 　
5 45.0 43.0 34.0 32.0 28.0 　 　 　 　
6 31.0 31.0 25.0 25.0 23.0 21.0 　 　 　
7 24.0 25.0 19.0 19.0 18.5 18.0 17.0 　 　
8 18.0 19.0 15.0 15.0 15.0 15.0 14.0 13.0 　
9 14.0 16.0 12.0 12.5 12.5 12.0 12.0 11.5 10.0
10 11.0 13.0 10.0 10.2 10.6 10.2 10.2 10.0 9.0
11 　 11.0 8.0 8.5 8.8 9.0 8.6 8.3 8.0
12 　 9.5 5.8 7.0 7.3 7.6 7.5 7.0 7.0
14 　 7.0 3.5 4.8 5.2 5.7 5.8 5.6 5.6
16 　 　 2.0 3.0 3.5 4.0 4.3 4.4 4.6
18 　 　
1.8 2.3 2.8 3.2 3.2 3.4
20 　 　 　
1.4 1.8 2.1 2.3 2.5
22 　 　 　

1.0 1.2 1.6 1.8
24 　 　 　 　


1.0 1.2
Magnification 14 11 8 5 5 4 4 4 3
Minimum luffing angle 180 210 340 410 450 520 540 580 580
Hook weight 100t hook/1.1t 50t hook/0.45t
Table 7(Counterweight: 15t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing angle of host boom (°) Host boom:48.2m+Auxiliary boom:11m Host boom: 48.2m+ Auxiliary boom: 18.5m
Auxiliary boom: 2° Auxiliary boom: 30° Auxiliary boom: 2° Auxiliary boom: 30°
Load capacity (t) Luffing range (m) Load capacity (t) Luffing range (m) Load capacity (t) Luffing range (m) Load capacity (t) Luffing range (m)
80 6.0 8.9 3.8 13.7 4.0 10.5 2.0 18.5
78 6.0 10.9 3.7 15.6 3.9 12.8 2.0 20.6
76 6.0 12.9 3.6 17.5 3.8 15.0 2.0 22.7
74 6.0 14.9 3.5 19.4 3.6 17.3 1.9 24.8
72 6.0 16.9 3.3 21.3 3.4 19.5 1.9 26.8
70 6.0 18.8 3.2 23.1 3.2 21.7 1.8 28.9
68 5.4 20.8 3.1 24.9 3.0 23.8 1.8 30.8
66 4.8 22.7 3.0 26.7 2.9 26.0 1.7 32.8
64 4.2 24.5 2.9 28.4 2.7 28.1 1.7 34.7
62 3.7 26.3 2.8 30.1 2.5 30.1 1.6 36.5
60 3.2 28.1 2.6 31.8 2.4 32.1 1.6 38.3
58 2.9 29.9 2.3 33.4 2.2 34.1 1.5 40.0
56 2.5 31.6 2.0 35.0 1.9 36.0 1.4 41.7
54 2.1 33.3 1.8 36.5 1.7 37.9 1.3 43.4
52 1.7 34.9 1.5 38.0 1.4 39.8 1.1 45.0
50 1.3 36.5 1.2 39.5 1.1 41.6 1.0 46.5
45 0.8 40.3 0.8 42.8 0.7 45.8

Table 8(Counterweight: 9t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing angle of host boom (°) Host boom: 48.2m+Auxiliary boom:11m Host boom: 48.2m+ Auxiliary boom:18.5m
Auxiliary boom: 2° Auxiliary boom: 30° Auxiliary boom: 2° Auxiliary boom:30°
Load capacity
(t)		 Luffing range (m) Load capacity (t) Luffing range (m) Load capacity (t) Luffing range (m) Load capacity (t) Luffing range (m)
80 6.0 8.9 3.8 13.7 4.0 10.5 2.0 18.5
78 6.0 10.9 3.7 15.6 3.9 12.8 2.0 20.6
76 6.0 12.9 3.6 17.5 3.8 15.0 2.0 22.7
74 6.0 14.9 3.5 19.4 3.6 17.3 1.9 24.8
72 6.0 16.9 3.3 21.3 3.4 19.5 1.9 26.8
70 6.0 18.8 3.2 23.1 3.2 21.7 1.8 28.9
68 5.4 20.8 3.1 24.9 3.0 23.8 1.8 30.8
66 4.8 22.7 3.0 26.7 2.9 26.0 1.7 32.8
64 4.0 24.5 2.9 28.4 2.7 28.1 1.7 34.7
62 3.4 26.3 2.6 30.1 2.5 30.1 1.6 36.5
60 2.8 28.1 2.3 31.8 2.2 32.1 1.5 38.3
58 2.3 29.9 1.9 33.4 1.8 34.1 1.4 40.0
56 1.8 31.6 1.5 35.0 1.4 36.0 1.1 41.7
54 1.4 33.3 1.1 36.5 1.1 37.9 0.8 43.4
52 1.0 34.9 0.8 38.0 0.8 39.8

50 0.7 36.5





Table 9(Counterweight: 2t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing angle of host boom(°) Host boom: 48.2m+Auxiliary boom:11m Host boom: 48.2m+ Auxiliary boom:18.5m
Auxiliary boom: 2° Auxiliary boom: 30° Auxiliary boom: 2° Auxiliary boom: 30°
Load capacity
(t)		 Luffing range (m) Load capacity (t) Luffing range (m) Load capacity (t) Luffing range (m) Load capacity (t) Luffing range (m)
80 6.0 8.9 3.8 13.7 4.0 10.5 2.0 18.5
78 6.0 10.9 3.7 15.6 3.9 12.8 2.0 20.6
76 6.0 12.9 3.6 17.5 3.8 15.0 2.0 22.7
74 6.0 14.9 3.5 19.4 3.6 17.3 1.9 24.8
72 6.0 16.9 3.3 21.3 3.4 19.5 1.9 26.8
70 6.0 18.8 3.2 23.1 3.2 21.7 1.8 28.9
68 5.4 20.8 3.1 24.9 3.0 23.8 1.8 30.8
66 4.8 22.7 3.0 26.7 2.9 26.0 1.7 32.8
64 4.0 24.5 2.9 28.4 2.7 28.1 1.7 34.7
62 3.4 26.3 2.6 30.1 2.5 30.1 1.6 36.5
60 2.8 28.1 2.3 31.8 2.2 32.1 1.5 38.3
58 2.3 29.9 1.9 33.4 1.8 34.1 1.4 40.0
56 1.8 31.6 1.5 35.0 1.4 36.0 1.1 41.7
54 1.4 33.3 1.1 36.5 1.1 37.9 0.8 43.4
52 1.0 34.9 0.8 38.0 0.8 39.8

50 0.7 36.5





Table 10 (Counterweight: 15t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing angle of host boom(°) Host boom: 48.2m+Auxiliary boom:11m Host boom: 48.2m+ Auxiliary boom:18.5m
Auxiliary boom: 2° Auxiliary boom: 30° Auxiliary boom: 2° Auxiliary boom: 30°
Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m)
80 6.0 8.9 3.8 13.7 4.0 10.5 2.0 18.5
78 6.0 10.9 3.7 15.6 3.9 12.8 2.0 20.6
76 6.0 12.9 3.6 17.5 3.8 15.0 2.0 22.7
74 6.0 14.9 3.5 19.4 3.6 17.3 1.9 24.8
72 5.7 16.9 3.3 21.3 3.4 19.5 1.9 26.8
70 5.0 18.8 3.1 23.1 3.2 21.7 1.8 28.9
68 4.4 20.8 2.9 24.9 2.9 23.8 1.7 30.8
66 3.6 22.7 2.6 26.7 2.6 26.0 1.6 32.8
64 2.9 24.5 2.2 28.4 2.3 28.1 1.5 34.7
62 2.3 26.3 1.9 30.1 1.9 30.1 1.3 36.5
60 1.8 28.1 1.5 31.8 1.5 32.1 1.0 38.3
58 1.4 29.9 1.1 33.4 1.1 34.1

56 1.0 31.6 0.8 35.0 0.8 36.0

Table11 (Counterweight: 15t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing angle of host boom(°) Host boom: 48.2m+Auxiliary boom:11m Host boom: 48.2m+ Auxiliary boom:18.5m
Auxiliary boom: 2° Auxiliary boom: 30° Auxiliary boom: 2° Auxiliary boom: 30°
Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m)
80 6.0 8.9 3.8 13.7 4.0 10.5 2.0 18.5
78 6.0 10.9 3.6 15.6 3.9 12.8 2.0 20.6
76 6.0 12.9 3.4 17.5 3.8 15.0 2.0 22.7
74 6.0 14.9 3.2 19.4 3.6 17.3 1.9 24.8
72 5.0 16.9 3.0 21.3 3.4 19.5 1.9 26.8
70 4.0 18.8 2.8 23.1 3.0 21.7 1.8 28.9
68 3.2 20.8 2.5 24.9 2.5 23.8 1.7 30.8
66 2.3 22.7 2.1 26.7 2.0 26.0 1.5 32.8
64 1.8 24.5 1.6 28.4 1.6 28.1 1.1 34.7
62 1.2 26.3 1.2 30.1 1.1 30.1 0.8 36.5
60 0.9 28.1 0.7 31.8 0.7 32.1

Table 12 (Counterweight: 2t, Full extended supporting legs, host boom in 3600 working) (unit: t)
Luffing angle of host boom(°) Host boom: 48.2m+Auxiliary boom:11m Host boom: 48.2m+ Auxiliary boom:18.5m
Auxiliary boom: 2° Auxiliary boom: 30° Auxiliary boom: 2° Auxiliary boom: 30°
Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m) Load capacity
(t)		 Luffing range (m)
80 6.0 8.9 3.8 13.7 4.0 10.5 2.0 18.5
78 6.0 10.9 3.6 15.6 3.7 12.8 1.9 20.6
76 5.0 12.9 3.4 17.5 3.4 15.0 1.8 22.7
74 4.0 14.9 3.0 19.4 3.0 17.3 1.7 24.8
72 3.0 16.9 2.3 21.3 2.3 19.5 1.5 26.8
70 2.2 18.8 1.7 23.1 1.6 21.7 1.1 28.9
68 1.5 20.8 1.1 24.9 1.1 23.8 0.7 30.8
66 1.0 22.7 0.7 26.7



Luffing curve

Related products